It is currently Mon 17 Dec 2018, 6:35 pm

All times are UTC + 10 hours [ DST ]




Post new topic Reply to topic  [ 55 posts ]  Go to page Previous  1, 2, 3
Author Message
 Post subject: Re: Custom console
PostPosted: Sun 12 Dec 2010, 5:45 pm 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
I now have a major headache...........I can get the power window (Drivers side) to come down one remote only...........It's wired to the battery with the remote controlling the earth..............I have tried many ways today, but if I wire the main switch to the loom it instantly blows the fuse.

The system worked before but now I'm scratching my head..........the remote system is wired independently of the main switch, but for some reason the every time I wire in the window the fuse blows.......not sure how this happens as the main switch requires an ignition 12V not battery voltage.

Can anybody help?


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Tue 14 Dec 2010, 6:41 pm 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
Obviously not............I can get it to work but need to relay off the main power to run the remote system with a NC relay.

The earth on switch block will also require a NO relay, so when the ignition is turned "on" the earth relay will close and the remote system "open" allowing isolation of the remote system.

It might be easier to use 5 pin switches rather than the 2 pin ones I currently have, makes for less to go wrong.

Does anybody have any VN-VP power window switches?


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Wed 15 Dec 2010, 2:08 pm 
Offline
1800 CORDIA
1800 CORDIA
User avatar

Joined: Tue 14 Oct 2008, 11:39 pm
Posts: 1152
Location: Karingal , Frankston Vic
Gender: Male
usually its a bad earth where the motor is or the motor is about to let go

_________________
AC silver bullet in the build, 4G62T DOHC

last cordia:
Blue 88 GSR turbo AC with 62t, TD05 14B and FMIC, 104wkw on 14psi
( I WOULD LIKE IT BACK IF POSSIBLE, OLD REG SYH354 )


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Thu 16 Dec 2010, 7:48 am 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
It's not the motor............got both systems working now.......but need another NO relay on the actual power window circuit to remove power from the motor once the remote system is added......If both wires are connected the motor pulls to many amps blowing the fuse..............you should see all the wiring!!!!


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Thu 16 Dec 2010, 10:51 am 
Offline
1800 CORDIA
1800 CORDIA
User avatar

Joined: Tue 14 Oct 2008, 11:39 pm
Posts: 1152
Location: Karingal , Frankston Vic
Gender: Male
I could imagine the wiring

_________________
AC silver bullet in the build, 4G62T DOHC

last cordia:
Blue 88 GSR turbo AC with 62t, TD05 14B and FMIC, 104wkw on 14psi
( I WOULD LIKE IT BACK IF POSSIBLE, OLD REG SYH354 )


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Thu 16 Dec 2010, 7:06 pm 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
All working perfect now.


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sat 18 Dec 2010, 9:24 pm 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
Project finished.

Image


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sat 18 Dec 2010, 10:46 pm 
Offline
Moderator
Moderator

Joined: Sat 02 Sep 2006, 12:05 pm
Posts: 2088
Location: Williamstown
Gender: Male
Your car: MY car? hmmm a black hunk of metal that moves once every year
So in the end u used cordia front, sigma back?

What did you use to join it? and cover it?

on a side note, what sort of paint did you use to paint the plastic trim, whats sort of prep is required?

I would like to try the same but in red, i have some beautiful red carpet im going to put in from my red cordia.

_________________
"hahhahahhaa its good its got straw for a pipe frontn.... the bigger that hole gets the more money falls out of ur wallet... "

metalcoremarc wrote:
works both ways mr big moderator sir.


Epic i must say.


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sat 18 Dec 2010, 11:51 pm 
Offline
This forum is my life
This forum is my life
User avatar

Joined: Sat 10 Jun 2006, 12:35 am
Posts: 3638
Location: Adelaide South Australia
Gender: Male
Your car: DOHC 2.3 VR4 85 AB GSR
Immaculate Stock 86 AC GSR
Terrence,
Yes.........it's the sigma rear cordia front.......both halves are fibreglassed together with a little bog to cover the join.........it was then prepared in "flexiprime" in order for the paint to stick.

K&N make the exact colour.......it's vinyl and plastic paint called charcoal.


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sun 19 Dec 2010, 3:06 pm 
Offline
Moderator
Moderator

Joined: Sat 02 Sep 2006, 12:05 pm
Posts: 2088
Location: Williamstown
Gender: Male
Your car: MY car? hmmm a black hunk of metal that moves once every year
thanks for the info mate. end product looks very good

_________________
"hahhahahhaa its good its got straw for a pipe frontn.... the bigger that hole gets the more money falls out of ur wallet... "

metalcoremarc wrote:
works both ways mr big moderator sir.


Epic i must say.


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sun 19 Dec 2010, 4:08 pm 
Offline
Super Cordia Guru
Super Cordia Guru
User avatar

Joined: Sun 23 May 2010, 8:31 pm
Posts: 730
Location: Andrews Farm, Adelaide SA
Gender: Male
Your car: Cordia Turbo AC GSR,
Wrecked AB GSR,
CB GSR,
VZ Acclaim Wagon
Agreed. Looks tough!

_________________
"BESSY"
SOLD


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Tue 21 Dec 2010, 8:02 pm 
Offline
Cordia Guru
Cordia Guru
User avatar

Joined: Thu 12 Jun 2008, 4:48 pm
Posts: 367
Location: Kilmore Victoria
Gender: Male
Love your work Andy, that car is definitely one of a kind!

_________________
Image


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Tue 21 Dec 2010, 11:26 pm 
Offline
Cordia Guru
Cordia Guru
User avatar

Joined: Mon 25 Dec 2006, 7:08 pm
Posts: 433
Location: Gold Coast, Australia
Your car: AC 1.8 multipoint 135fwk
Looking good.............cant have much left to do on it now....
...maybe electric seat adjustment..... i know you want more wiring :lol:
cheers

_________________
One step closer to the end...........
...............deceased and cremated


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Tue 21 Dec 2010, 11:59 pm 
Offline
Super Cordia Guru
Super Cordia Guru
User avatar

Joined: Mon 08 Aug 2005, 11:44 pm
Posts: 788
Location: carrum downs Melb
Your car: 1984 AA customer paint and some small custome body mods
looks top notch mate that is a one of a kind cordia, keep it up

_________________
For Sale
AA White GSR, hiflow TC06, reco Motor, 3inch exhause, k&n air cleaner
viewtopic.php?f=5&t=16477
All my Cordia Parts For Sale make an Offer
viewtopic.php?f=6&t=15917


Top
 Profile  
Reply with quote  
 Post subject: Re: Custom console
PostPosted: Sat 30 Apr 2011, 9:20 am 
Offline
Cordia Guru
Cordia Guru
User avatar

Joined: Tue 18 Sep 2007, 5:16 am
Posts: 395
Location: sydney
blown away mate, very impressive work. you have come up with some really good mods!

_________________
Image

http://www.cardomain.com/ride/2541897


Top
 Profile  
Reply with quote  
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 55 posts ]  Go to page Previous  1, 2, 3

All times are UTC + 10 hours [ DST ]


Who is online

Users browsing this forum: No registered users and 5 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Search for:
Jump to:  
cron



Connect with Cordia Power on Facebook. Cordia Power 2000-2018. Cordia Forum powered by phpBB.